Honda Car Forum

The Honda's clutch pedal clicks and creaks when depressed (or even when it
is in a good mood). I would be grateful for any insight about what the
problem is and how to fix it.
Thanks!

On Mon, 07 May 2007 14:43:50 -0500, Enrico Fermi wrote:

> The Honda's clutch pedal clicks and creaks when depressed (or even when it
> is in a good mood). I would be grateful for any insight about what the
> problem is and how to fix it.
> Thanks!


Some Nuclear Physicist! Can't even figure out a clutch pedal! Good thing
Little boy didn't burn the atmosphere!

At any rate, I would look at a couple of things. From what you're
describing the first thing I would look at would be the pin that holds the
clutch pedal onto the bracket. It may have some teflon or similar plastic
bushings and they are wearing out. Or, the pin or the bracket my be
rusting (this has happened to me before, and if it's getting wet, you have
bigger fish to fry. On one car it was caused by a windsheild replacement
that just would not seal, and on another it was because the windshield
frame/cowling/firewall was rotting out and allowing water into the car)

The next thing (or, perhaps, the first thing) is the spring. It may also
have gotten wet, or has shifted and is binding against itself somehow. It
may need to be 'reseated', which means merely moving it back to where it
should be without removing it. I would also grease while I'm down there.

Also, check the connection to the plunger that runs through the firewall
to the clutch Master Cylinder, and check the boot, too while you're at it.
The boot may be allowing water onto the plunger and again, may be rusting
where it is joined to the pedal. Check for bushings and grease it if you
can.

Beyond that, we're into the Master Cylinder, and it may need replacement.
But I doubt it goes that far. More likely one of the other things I
mentioned.

Good Luck!

"Enrico Fermi" <none@nowhere.net> wrote in
news:463f8177$0$4862$4c368faf@roadrunner.com:

> The Honda's clutch pedal clicks and creaks when depressed (or even
> when it is in a good mood). I would be grateful for any insight about
> what the problem is and how to fix it.
> Thanks!
>
>


Grease the pedal return spring.

--
Tegger

The Unofficial Honda/Acura FAQ
www.tegger.com/hondafaq/

On Wed, 9 May 2007 22:40:03 +0000 (UTC), Tegger <tegger@tegger.c0m>
wrote:

>"Enrico Fermi" <none@nowhere.net> wrote in
>news:463f8177$0$4862$4c368faf@roadrunner.com:
>
>> The Honda's clutch pedal clicks and creaks when depressed (or even
>> when it is in a good mood). I would be grateful for any insight about
>> what the problem is and how to fix it.
>> Thanks!
>>
>>
>
>
>Grease the pedal return spring.

The master cylinder might be the cause. See Honda Service Bullitin
02-002.

Skate <skat3e123NOSPAM@yahoo.net> wrote in
news:8op4431lkkbj4849o5b2d8842jvahflg3l@4ax.com:

> On Wed, 9 May 2007 22:40:03 +0000 (UTC), Tegger <tegger@tegger.c0m>
> wrote:
>
>>"Enrico Fermi" <none@nowhere.net> wrote in
>>news:463f8177$0$4862$4c368faf@roadrunner.com:
>>
>>> The Honda's clutch pedal clicks and creaks when depressed (or even
>>> when it is in a good mood). I would be grateful for any insight about
>>> what the problem is and how to fix it.
>>> Thanks!
>>>
>>>
>>
>>
>>Grease the pedal return spring.
>
> The master cylinder might be the cause. See Honda Service Bullitin
> 02-002.
>


Now why didn't I think to check the TSBs?

Excerpts from that TSB:

PROBABLE CAUSE
The clutch master cylinder spring is rubbing on the
outer diameter of the piston when the pedal is pressed,
or the master cylinder quick connect is moving.

CORRECTIVE ACTION
Replace the master cylinder, and apply a thin film of
silicone grease to the clutch line fitting.

--
Tegger

The Unofficial Honda/Acura FAQ
www.tegger.com/hondafaq/